Study of structural, optical and electrical properties of ZnO/CuO nanocomposites

Document Type : Original Article

Authors

Abstract

In this work, the first ZnO/CuO nanocomposites were synthesized by chemical vapour deposition (CVD), thermal evaporation (PVD) and sputtering on silicon substrates (Si). Then, the structural, optical and electrical properties of the samples were investigated. Examination of the X-ray diffraction patterns confirmed the mixed-phase formation of hexagonal zinc oxide (ZnO) and monoclinic copper oxide (CuO) phases, resulting in the formation of ZnO/CuO composite in all methods. The plan view images obtained from FESEM analysis showed that the morphology of the samples prepared by the CVD method differs from other samples and is as nanowires with an average radius of about 400 nm. Examining the samples' optical properties showed that their bandgap is in the range of 2.05 eV-2.18 eV, which is larger than the bandgap of copper oxide (1.2 eV) and smaller than zinc oxide (3.3 eV). The composite synthesized by the CVD method has the lowest reflectance, and the sample prepared by the PVD method has the highest reflectance in the visible and near-infrared ranges. Examination of the room temperature photoluminescence (PL) spectrum of the sample prepared by PVD showed that these samples have emission peaks with significant intensities in the ultraviolet and visible ranges. The samples' electrical properties showed that the ZnO/CuO composite synthesized by sputtering and CVD had the lowest and highest electrical resistance, respectively. The samples' optical response study showed that the sputtering method's nanocomposites have the highest response. This study showed that, in general, the structural, optical and electrical properties and morphology of synthesized ZnO/CuO composites are significantly affected by their synthesis method.

Keywords


[1] Mehta S. K., et al. "Ultra-high sensitive hydrazine chemical sensor based on low-temperature grown ZnO nanoparticles." Electrochimica acta 69 (2012): 128-133.

[2] Fatemi Hengameh, et al. "Apple–biomorphic synthesis of porous ZnO nanostructures for glucose direct electrochemical biosensor.", Current Applied Physics 12.4 (2012): 1033-1038.

[3] Khan Sher Bahadar, et al. "Low-temperature growth of ZnO nanoparticles: photocatalyst and acetone sensor.", Talanta 85.2 (2011): 943-949.

[4] Anas S., et al. "Sintering of surfactant modified ZnO–Bi2O3 based varistor nanopowders.", Ceramics International 36.8 (2010): 2351-2358.

[5] Zhu Ping, et al. "Biomedical applications of functionalized ZnO nanomaterials: From biosensors to bioimaging.", Advanced Materials Interfaces3.1 (2016): 1500494.

[6] Zang Zhigang, Xiaosheng Tang, "Enhanced fluorescence imaging performance of hydrophobic colloidal ZnO nanoparticles by a facile method" Journal of Alloys and Compounds 619 (2015): 98-101.

[7] Zang Zhigang, et al. "Femtosecond laser direct writing of microholes on roughened ZnO for output power enhancement of InGaN light-emitting diodes.", Optics letters 41.15 (2016): 3463-3466.

[8] Chen Yalu, et al. "A CuO–ZnO nanostructured p–n junction sensor for enhanced N-butanol detection.", RSC advances 6.3 (2016): 2504-2511.

[9] Khan Muhammad Arif, et al. "Catalyst-free fabrication of novel ZnO/CuO core-Shell nanowires heterojunction: Controlled growth, structural and optoelectronic properties", Applied Surface Science435 (2018): 718-732.

[10] Jagadish Chennupati, Stephen J., Pearton eds., “Zinc oxide bulk, thin films and nanostructures: processing, properties, and applications”, Elsevier, 2011.

[11] Zeng Zaiping, et al. "Linear and nonlinear optical properties of ZnO/ZnS and ZnS/ZnO core shell quantum dots: effects of shell thickness, impurity, and dielectric environment", Journal of Applied Physics 114.2 (2013): 023510.

[12] Zhai Jing, et al. "Core/shell structured ZnO/SiO2 nanoparticles: preparation, characterization and photocatalytic property." Applied Surface Science 257.2 (2010): 393-397.

[13] Abraham Nelsa, et al. "Dye sensitized solar cells using catalytically active CuO-ZnO nanocomposite synthesized by single step method.", Spectrochimica Acta Part A: Molecular and Biomolecular Spectroscopy 200 (2018): 116-126.

[14] Kim Jaehyun, Wooseok Kim, Kijung Yong, "CuO/ZnO heterostructured nanorods: photochemical synthesis and the mechanism of H2S gas sensing.", The Journal of Physical Chemistry C 116.29 (2012): 1568215691.

[15] Filipič G., U. Cvelbar, "Copper oxide nanowires: a review of growth" Nanotechnology 23.19 (2012): 194001.

[16] Paul Somdatta, et al. "Investigation of the comparative photovoltaic performance of n-ZnO nanowire/p-Si and n-ZnO nanowire/p-CuO heterojunctions grown by chemical bath deposition method.", Optik 164 (2018):745-752.

[17] Zangeneh H., Zinatizadeh A.A.L., Habibi M., Akia M., Isa M.H., "Photocatalytic oxidation of organic dyes and pollutants in wastewater using different modified titanium dioxides: A comparative review.", J. Ind. Eng. Chem. 26 (2015): 1–36

[18] L. Zhu, H. Li, Z. Liu, P. Xia, Y. Xie, D. Xiong, "Synthesis of the 0D/3D CuO/ZnO heterojunction with enhanced photocatalytic activity."و J. Phys. Chem. C. 122 (2018): 9531–9539.

[19] P.S. Kumar, M. Selvakumar, S.G. Babu, S. Induja, S. Karuthapandian, "CuO/ZnO nanorods: An affordable efficient p-n heterojunction and morphology dependent photocatalytic activity against organic contaminants."و J. Alloys Compd. 701 (2017): 562-573.

[20] Barokah S., Widiarti N., "Photocatalytic activity CuO-ZnO on oxidation reaction of PhenolIndo.", J. Chem Sci. 4 (2015): 88

[21] Wang J.X., Sun X.W., Yang Y., AKyaw K.K., Huang X.Y., Yin J.Z., Wei J., Demir H.V., "Free-standing ZnO-CuO composite nanowire array films and their gas sensing properties.", Nanotechnology 22 (2011): 325704.

[22] Yan Xiu-Tian, Yongdong X.u., “Chemical vapour deposition: an integrated engineering design for advanced materials”, Springer Science & Business Media, 2010.

[23] Dion CA Dorval, Jason Robert Tavares, "Photo-initiated chemical vapor deposition as a scalable particle functionalization technology (a practical review).", Powder technology 239 (2013):484-491.

[24] Ohering M., "Materials science of thin films deposition and structure.", (2002): 215.

[25] Fu Qiu-Ming, et al. "Self-powered ultraviolet photodetector based on ZnO nanorod arrays decorated with sea anemone-like CuO nanostructures.", Materials Letters 222 (2018): 74-77.

[26] López-Romero S., M. García-H., "Photoluminescence and structural properties of ZnO nanorods growth by assisted-hydrothermal method.", (2013).

[27] Huang Michael H., et al. "Catalytic growth of zinc oxide nanowires by vapor transport.", Advanced Materials 13.2 (2001): 113-116.

[28] Prabhu Yendrapati Taraka, et al. "X-ray analysis by Williamson-Hall and size-strain plot methods of ZnO nanoparticles with fuel variation", World Journal of Nano Science and Engineering2014 (2014).

[29] Monshi Ahmad, Mohammad Reza Foroughi, Mohammad Reza Monshi, "Modified Scherrer equation to estimate more accurately nano-crystallite size using XRD.", World journal of nano science and engineering 2.3 (2012): 154-160.

[30] Li Hong, et al. "Synthesis and investigation of novel ZnO–CuO core-shell nanospheres", Materials Letters 174 (2016): 99-101.

[31] Kumaresan N., M. Maria Angelin Sinthiya, K. Ramamurthi, R. Ramesh Babu, K. Sethuraman, "Visible light driven photocatalytic activity of ZnO/CuO nanocomposites coupled with rGO heterostructures synthesized by solid-state method for RhB dye degradation.", Arabian Journal of Chemistry 13, no. 2 (2020): 3910-3928.

[32] Sharma Mahima, Mrinal Poddar, Yash Gupta, Subhasha Nigam, Devesh Kumar Avasthi, Rainer Adelung, Reza Abolhassani, Jacek Fiutowski, Monika Joshi, Yogendra Kumar Mishra, "Solar light assisted degradation of dyes and adsorption of heavy metal ions from water by CuO–ZnO tetrapodal hybrid nanocomposite.", Materials Today Chemistry 17 (2020): 100336.

[33] Saini Sandhya, Yendrapati Taraka Prabhu B., Sreedhar Pankaj Kumar Prajapati, Ujjwal Pal, Suman L. Jain, "Visible light induced α-amino acid synthesis from carbon dioxide using nanostructured ZnO/CuO heterojunction photocatalyst.", Materialia 12 (2020): 100777.

[34] Allabergenov Bunyod, et al. "Effective control over near band-edge emission in ZnO/CuO multilayered films.", Optical Materials Express 7.2 (2017): 494-502.

[35] Lavin Alexis, et al. "High proportion ZnO/CuO nanocomposites: Synthesis, structural and optical properties, and their photocatalytic behavior", Surfaces and Interfaces 17 (2019): 100367.

[36] Tang Chunmei, et al. "Facile synthesis and nanoscale related physical properties of core-shell structured CuO/ZnO nanorods on Si substrate", Applied Surface Science 509 (2020): 144903.

[37] Park Young Jae, et al. "Solution-processed multidimensional ZnO/CuO heterojunction as ultraviolet sensing", Optical Materials Express 5.8 (2015):1752-1758.